MAGNUM COUNTRYSIDE® BIOMASS CORN/WOOD PELLET STOVE /FIREPLACE INSERT Safety tested and EPA exemption tested by Omni-Test Laboratories, Inc to UL 1482,
10 The stove must be installed with the following minimum clearances to side and back wall combustible materials. NOTE: These are minimum clearanc
11 It is recommended that only an authorized MagnuM Countryside installer install your pellet/corn stove. The following installation guidelines mus
12GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN, CONT…… To determine whether a 3” or 4” exhaust system should be used, follow the guidelines below:
13OUTSIDE MAKE-UP AIR FOR COMBUSTION IS REQUIRED ON ALL INSTALLATIONS 1) For FREESTANDING installations with horizontal through-the-wall exhaust, i
14INSTALLATION PRECAUTIONS CAUTION: Do not install this appliance in any manner other than as described in this manual. If you have any questions
15VENT TERMINATION GENERAL INSTRUCTIONS NOTE: The following are general instructions for installing this appliance. THE VENT PIPE MANUFACTURER’S I
16 The MagnuM Countryside Biomass Corn/Pellet Stove / Fireplace Insert may be installed as follows: 1) A freestanding unit 3500P & 3500L mod
17ALCOVE INSTALLATION REQUIREMENTS The MagnuM Countryside is approved for the standard alcove height of 72 inches, or for a reduced alcove height w
18FREESTANDING STOVE INSTALLATION REQUIREMENTS Horizontal Exhaust Termination: 1) Locate proper position for the type “PL” wall thimble (F). Use
19 Locate so that exhaustdoes not interfere withfresh air Storm Collar Required Required
2TABLE OF CONTENTS PAGE CLEAN BURN (special additive) ………………………………………………..………….. 3 INTRODUCTION & SPECIFICATIONS………….………………………………………... 4 IMPO
20 WARNING: Unless the venting is enclosed and insulated this installation will cause poor venting and serious creosote buildup in cold climate area
21FIREPLACE INSERT INSTALLATION REQUIREMENTS The MagnuM Countryside Model 3502 Fireplace Insert may be installed in a masonry factory built fireplac
22FIREPLACE INSERT INSTALLATION CONTINUED…… The MagnuM Countryside Model 3502 Fireplace Insert requires a fireplace shroud for proper installation.
23 Your MagnuM Countryside Corn/Pellet Stove comes to you with the glass door installed in place, ready for use. The glass is surrounded on the e
24 Front view Left view Side view showing control operation Adjustable Air Deflector Move up o
25 9 Turn the Fuel Stirrer kn
26 Startup When the circuit board is energized (unit plugged in) there is a 15 second purging of the auger tube to allow fuel to enter the firepot.
27 A proper draft setting is crucial to the successful burning of solid fuels. Draft refers to the amount of air flowing through the burn chamber
28 9 Using the clean-out tool, tap the side heat exchangers that are located on the left and right sides of the firebox. When you open the door,
29 WEEKLY MAINTENANCE 9 Set the stove on high fire. Open the draft to 100% and allow the stove to burn for 15 minutes. Resume desired heat
3 CLEAN BURN CORN ADDITIVE TM AMERICAN ENERGY SYSTEMS INC. HAS DEVELOPED AN ADDITIVE THAT WHEN MIXED WITH CORN VIRTUALLY ELIMINATES THE (CLIN
30 9 Cleaning of the exhaust system will depend upon the ash and debris content of your fuel. If your fuel has a high ash content and/or significan
31 SPRING CLEANING: When the heating season is over make sure that you clean out all of the fuel in the hopper, firebox area, ash pan and firepot
32 The hopper auger safety switch is mounted in the back of the hopper, up next to the back lid. The assembly is enclosed to keep the fuel
33 9 The MagnuM Countryside can be installed with and operated by a wall-mounted thermostat. However, a wall thermostat is not provided wit
34 PROBLEM CAUSES SOLUTIONS Fire burns with a lazy, orange flame and/or fuel builds up in the grate and the window gets sooted up. ♦ Insuffici
35PROBLEM CAUSES SOLUTIONS ? Fire goes out or stove shuts down automatically. ♦ Hopper is empty. ♦ Fuel is not feeding. ♦ High limit temper
36PROBLEM CAUSES SOLUTIONS ? Blower will not operate. ♦ No power to stove. ♦ No power to control board. ♦ Blower has overheated du
37 IMPORTANT: Electrical work must be performed by an authorized technician. PROBLEM CAUSES SOLUTIONS Fuel burns off to quickly, have difficulty
38 WARNING: This section is only for qualified technicians. Countryside Wiring Diagram (Ortech Circuit Board) MF3537 low temperature norm
39 If the low fire heat setting is too low for the fuel that you are burning and the fire goes out, the number 1 or 2 heat setting can be ad
4DEAR VALUED COUNTRYSIDE OWNER, We appreciate your decision to help preserve our precious environment by purchasing the MagnuM Countryside Biomass C
40 DRAFT SLIDE GATE ADJUSTMENT NOTE: The draft slide gate plate does not come as a standard piece with the unit. This must be purchased separate i
41 MAGNUM COUNTRY SIDE REPLACEMENT PARTS LIST ORDER # DESCRIPTION MF3511 Bronze Bushing (fuel stirrer shaft bearing) 2 pcs. (all countr
42MAGNUM COUNTRY SIDE REPLACEMENT PARTS LIST Cont. ORDER # DESCRIPTION P6092 Fuel stirrer retaining collar P003088 ½” ID Shaft Collar P0030
43 AMERICAN ENERGY SYSTEMS INC. LIMITED PRODUCT WARRANTY This warranty is in effect on all product
44SERVICE RECORD DATE SERVICE OR CLEANING PERFORMED
5Importance of adequate fresh Combustion Air Every home is a slightly different situation and depending on the design of the air movement within th
IMPORTANT: Proper installation of this stove is crucial for proper and safe operation. Installing this product improperly may result in a house
7 Unlike petroleum and natural gas products, solid fuels such as corn and wood pellets create ash as the fuel is burned. Even with the highly eff
89 There are many varieties of corn grown around the world. Each variety has unique characteristics including the shape and size of the kernel. Yo
9To uncrate you’re MagnuM Countryside Corn/Pellet Stove: 1) Cut the banding straps and open the carton lid. The carton is stapled to the wood palle
Commentaires sur ces manuels